InstaMix

InstaMix (InstaMix IC)

InstaMix

InstaMix Iodine Concentrate IC (Part A) is an iodine concentrate exclusively designed for use in combination with InstaMix Emollient Concentrate EC (Part B) for on-site blending / production of teat dips. To be blended with a DeLaval recommended on-site blending unit.

ACTIVE INGREDIENTS:

Iodine………………………. 5.2%

Emollient‍*………………… 8.5%

*From Glycerin

STORAGE AND DISPOSAL

  • THOROUGHLY RINSE ALL MEASURING DEVICES AND STORE OUT OF REACH OF CHILDREN.
  • Avoid contact with food or feed. Avoid storing near heat or open flame.
  • Keep from freezing.
  • If product is frozen, thaw in warm room and mix well before using.
  • Keep container tightly closed when not in use.
  • Do not reuse empty container.
  • Rinse empty container before disposing in a safe manner.

GENERAL INSTRUCTIONS

  • Do not use full strength.
  • Consult veterinarian before starting or continuing to use teat dip if cow’s teats are sore or chapped.
  • Do not use teat dip for cleaning and/or sanitizing of dairy equipment.
  • Discard any teat sanitizing solution that becomes dirty or contaminated for any reason.
  • Good dairy practices suggest the thorough cleaning and sanitizing of teats before milking to avoid contamination and assist in the control of mastitis.
  • To be mixed with InstaMix Emollient Concentrate EC (Part B) using a DeLaval recommended on-site blending unit. Can be diluted to create 18 formula options.

USE DIRECTIONS

  • Pre-Dipping
  • Remove excess organic debris and forestrip.
  • Dip or spray cow’s teats with properly diluted teat dip prepared with the DeLaval recommended on-site blending unit.
  • Allow a 30 second contact time.
  • Dry teats thoroughly with a clean, single-service paper towel.
  • Attach milker unit.

Post-Dipping

  • Immediately after removing the milker unit, dip or spray each teat with properly diluted teat dip prepared with a DeLaval recommended on-site blending unit.
  • Before exposing cow’s teats to below freezing temperatures, the teats should be thoroughly dry to reduce the potential of frostbite. Failure to follow theseinstructions may result in frozen teats and injured animals.

IMPORTANT!

  • 0.25% teat dip must be mixed on demand.
  • 0.5% – 1.0% teat dip must be used within two weeks after mixing.
  • Discard unused mixtures after above noted times.

FIRST AID

  • Contact with product can cause irritation to eyes. Avoid contact with eyes.
  • Eye Contact: Flush with water.
  • If swalled: Do not induce vomiting. Call a physician or poison control center immediately.

Leave a Reply

Gafacom
%d bloggers like this: